hitung gpm water to ton of ore
hitung gpm water to ton of ore
Zhengzhou, Henan China
24 hours At your service

hitung gpm water to ton of ore

Convert ton/hr to gal/min tonne (water mass) per hour to ...

Diferent flow rate units conversion from tonne (water mass) per hour to gallons US per minute. Between ton/hr and gal/min measurements conversion chart page. Convert 1 ton/hr into gallon US per minute and tonnes (water mass) per hour to gal/min. The other way around, how many gallons US per minute - gal/min are in one tonne (water mass) per hour - ton/hr unit?

More

Estimated Water Requirements for the Conventional ...

the amount of water required to process copper sulfide ore through a conventional crush-grind-flotation-concentrate circuit ranges from roughly 1.5 metric tons (t) to about 3.5 t of water to process 1 t of ore [Wels and Robertson, 2003, 2004; Misra and others, 2005; Wills and Napier-Munn, 2006; Chilean

More

TECH TIP #51 - Federal Corporation

BTU/Hr. = GPM X 500 X Temp Rise Typical chilled water system design flow rates 2.4 GPM per ton (assuming 10oF difference between entering and leaving temperatures) Evaporation rate of cooling tower condenser water 3 GPM per 100 tons Condenser water flow rate requirement 3 GPM per ton BTU per ton of cooling 12,000 BTU = 1 ton

More

Is there a "magic number" GPM flow rate per ton ...

Nov 21, 2010  Ok. thanks. The manual for the system says that flow rates above 3 gpm per ton can actually cause water velocities in the exchanger that can erode the walls of the exchanger and cause leaks! I didn't know if I should/could throttle down the flow using the manifold in order to get about 3 to 3.5 gpm per ton.

More

Chilled Water GPM per Ton - HVAC/R engineering - Eng-Tips

May 01, 2002  Typically for chillers systems, 2 GPM/ton is usually the evaporator flow and 3 GPM/ton is usually the condenser flow. These rates came about because they correspond to the temperature change of the water in the system. The 2 GPM/ton evaporator flow rate is a system with a 12 degree delta T (i.e. 44 degree supply water and 56 degree returned to ...

More

FORMULA SHEETS CONVERSION FACTORS

May , 1995 FORMULA SHEETS CONVERSION FACTORS Pi (ð) = 3.14 1 gallon of water = 8.34 pounds 1 gallon of water = 4 quarts = 8 pints = 3.785 liters

More

Water Evaporator and Condenser Equations

Condenser water flow rate can be expressed as. q cond = 30 h cond / dt (3) where. q cond = condenser water flow rate (gallons per minute - gpm) h cond = air condition load, chiller tonnage (1 cooling tower ton = 1 TONS evap = 1 TONS cond x 1.25 = 15,000 Btu/h = 3,782 k Calories/h = 15,826 kJ/h)

More

Attachment 2.4 - Water in the AMT Operation.

the basis of 30% water retention in the post AMT ore product and 10% water retention in the sand waste. The post AMT ore material is estimated to be approximately 20% of the total mass of material processed, i.e., a 20 ton/hour processing rate will produce approximately 4 tons of post AMT ore

More

Is there a "magic number" GPM flow rate per ton ...

Nov 21, 2010  Ok. thanks. The manual for the system says that flow rates above 3 gpm per ton can actually cause water velocities in the exchanger that can erode the walls of the exchanger and cause leaks! I didn't know if I should/could throttle down the flow using the manifold in order to get about 3 to 3.5 gpm per ton.

More

HYDROGEOLOGY OF THE HOMESTAKE MINE

ore contained an average concentration of 0.3 ounces of gold per ton. There-fore the tonnage mined = 40 X 106 oz/0.3 oz/ton = 133 X 106 ton. In addition to the voids created by mining the ore (per se), "waste rock" was also removed. We assume the waste rock amounted to 25% of the vol-ume of ore

More

AMIT 135: Lesson 2 Circuit Mass Balancing – Mining Mill ...

M w = water weight; This equation is often used to determine the amount of water in a process stream1 knowing the solids concentration by weight and the tons/hr of solids in a process stream. Solids Concentration Example. The underflow stream from the classifying cyclone bank contains 100 tons/hour of ore which represents 45% of the total ...

More

Simulating Underground Mine Inflows and Dewatering

Ground water storage is the principal component of the mine area water balance under mining conditions. Ground water inflow from storage to the mine, which increased to about 800 gpm by June 2001, exceeds the recharge rate. The occurrence of ground water is structurally compartmentalized. Faults, dikes, and sills intercepted

More

How to SIZE a Sluice Box - Mineral Processing Metallurgy

1000 gpm for a unit that’s only processing a ton per hour of very fine sand and/or grindings seems unnecessary and imbalanced. We easily process several yards of gravel per hour with a 12” wide sluice box on 120 to 150 gpm. If you can’t reduce water flow, I’d

More

roo roND

are used as process water. Currently, make-up water is added to the process stream at a rate of 300 gpm, during the flushing phase of the leach operation. GHC BULLETIN, SUMMER 1990 At the Florida Canyon Mine currently (1990) 14,000 tons per day of ore are loaded on the heap. The ore is crushed to

More

Silverton Homes for Sale: Silverton, OR Real Estate Redfin

Conveniences of the city with the privacy and peacefulness of the country! 35 GPM well, a fresh spring w/ a 10,000 gallon holding tank for live stock. 44x 31 red barn, 22 x 56 out building- siding and metal roof replaced in 2020. Natural gas line runs out 20x40 green house. Acreage is absolutely gorgeous!

More

Water Pump Testing Confirms Up to 547 gpm and Sufficient ...

Oct 05, 2017  When Viceroy operated the mine from 1992 to 2001 they pumped on average 210 gpm of water to process an average of 9,900 tons of ore per day. Their maximum water extraction rate was of 304 gpm

More

Keeping Our Streams Flowing: Tonto National Forest ...

mine 100 million tons (90.7 million metric tons) of ore from open pits over a twenty-year period to produce 900 million pounds (409 million kg) of copper. The ore would be leached with a sulfuric acid solution in a heap leach process. Water requirements for the mine average 590 gallons per minute (gpm) [1,926 liters per minute (Lpm)]

More

Projected Consumption of Electricity and Water by the ...

would process 150,000 metric tons of ore per day from an ore body at a depth of 5000-7000 feet ... geothermal water at a temperature of 170°F began entering the shaft at a rate of 460 gallons per minute (gpm). According to Tom Goodell, general manager – shaft development for Resolution ... water could increase from the 3800 gpm that would ...

More

Water Pollution Control Permit Long Canyon Project 1655 ...

Leach Pad Ore (LO); Ore Shipped Off-site Profile 1(2), water and collar elevation (feet amsl), and depth to water (feet bgs) MWMP4 -Profilej(2) and ANP/AGPt3; Amount of ore F—-3. Nevada Gold Mines LLC Long Canyon Project Permit N° NOV20 14110 (Renewal 2020, Revision 00) Pae 3 of 17 Parameter-— Frequency Quarterly WeeklyW Quarterly ...

More

Keeping Our Streams Flowing: Tonto National Forest ...

mine 100 million tons (90.7 million metric tons) of ore from open pits over a twenty-year period to produce 900 million pounds (409 million kg) of copper. The ore would be leached with a sulfuric acid solution in a heap leach process. Water requirements for the mine average 590 gallons per minute (gpm) [1,926 liters per minute (Lpm)]

More

Is there a "magic number" GPM flow rate per ton ...

Nov 21, 2010  Ok. thanks. The manual for the system says that flow rates above 3 gpm per ton can actually cause water velocities in the exchanger that can erode the walls of the exchanger and cause leaks! I didn't know if I should/could throttle down the flow using the manifold in order to get about 3 to 3.5 gpm per ton.

More

AMIT 135: Lesson 2 Circuit Mass Balancing – Mining Mill ...

M w = water weight; This equation is often used to determine the amount of water in a process stream1 knowing the solids concentration by weight and the tons/hr of solids in a process stream. Solids Concentration Example. The underflow stream from the classifying cyclone bank contains 100 tons/hour of ore which represents 45% of the total ...

More

HYDROGEOLOGY OF THE HOMESTAKE MINE

ore contained an average concentration of 0.3 ounces of gold per ton. There-fore the tonnage mined = 40 X 106 oz/0.3 oz/ton = 133 X 106 ton. In addition to the voids created by mining the ore (per se), "waste rock" was also removed. We assume the waste rock amounted to 25% of the vol-ume of ore

More

Simulating Underground Mine Inflows and Dewatering

Ground water storage is the principal component of the mine area water balance under mining conditions. Ground water inflow from storage to the mine, which increased to about 800 gpm by June 2001, exceeds the recharge rate. The occurrence of ground water is structurally compartmentalized. Faults, dikes, and sills intercepted

More

Projected Consumption of Electricity and Water by the ...

would process 150,000 metric tons of ore per day from an ore body at a depth of 5000-7000 feet ... geothermal water at a temperature of 170°F began entering the shaft at a rate of 460 gallons per minute (gpm). According to Tom Goodell, general manager – shaft development for Resolution ... water could increase from the 3800 gpm that would ...

More

roo roND

are used as process water. Currently, make-up water is added to the process stream at a rate of 300 gpm, during the flushing phase of the leach operation. GHC BULLETIN, SUMMER 1990 At the Florida Canyon Mine currently (1990) 14,000 tons per day of ore are loaded on the heap. The ore is crushed to

More

UNITED STATES DEPARTMENT OF THE INTERIOR

Sedimentary bedrock units generally yield sufficient water for domestic supply and, in places, may yield more than 100 gallons per minute to large-diameter wells.P. In the glacial deposits, sand and gravel beds are the principal aquifers; yields to wells range from less than 10 to 200 gallons per minute

More

ORO Concentrators - Global Mining Equipment

Oro's Helix Sprial concentrators can achieve the highest concentration ratio AND recovery possible with any type of ore that can be concentrated by gravity. The design and engineering principles of the multi-helix spirals inside the concentrator allow for full adjustment to the ore-matrix or concentrate, yielding the peak concentration ratio ...

More

Silverton Homes for Sale: Silverton, OR Real Estate Redfin

Conveniences of the city with the privacy and peacefulness of the country! 35 GPM well, a fresh spring w/ a 10,000 gallon holding tank for live stock. 44x 31 red barn, 22 x 56 out building- siding and metal roof replaced in 2020. Natural gas line runs out 20x40 green house. Acreage is absolutely gorgeous!

More

Borehole Mining of Manganese in Emily MN

Water is jetted into the formation at @ 1,200 formation at @ 1,200 –– 1,800 psi. The tool head rotates. 2. Sloughed deposit settles to the bottom ofsettles to the bottom of the borehole. 3. The slurry is pumped out screened andout, screened, and filtered at the surface. 4. Clear water is reClear water is re--ij td t jtinjected as water jet

More

LEACHING OF SILVER AND GOLD ORES AT SMOKY VALLEY

Jan 01, 1982  MINING The open pit mine operates three shifts per day, seven days per week to produce approximately 7,000 tons ore and 35,000 tons waste and lean ore daily. 25,000 tons of the waste is advanced stripping for an extension of the ore body that is scheduled to be the major source of ore by 1983. The pit is being mined with 35-foot benches.

More

Heap Mining Efficiently Leaches Lower Grade Gold from S

Most mines will have 2-3 tons of waste material to 1 ton of ore. This waste must be taken to a separate dump. This is called the “strip ratio” and is a very important aspect in developing and operating a heap leach mine. If a mine has a 3-1 strip ratio, 164 tons of material

More

The Application of Water Jets in Coal Mining

flow rate up to 1,500 gallons per minute water jet system produced up to 3,400 tons per manshift. The third method of mining is an experimental program being carried out by Flow Research, Inc. in Washington state. With this method coal is mined from underground seams to boreholes driven from the surface, coal being reamed to

More